Hayati Pro Max Plus 6K replacement pods, the complete UK flavour, fit and running cost guide

Written and reviewed by Daniel Marsh, Senior product reviewer at Prefilled Vapes Outlet

Hayati Pro Max Plus 6K replacement pods are sealed refill sets for the Hayati Pro Max Plus 6000 kit, each set holding 12ml of e liquid across a 2ml pod and a 10ml refill container, rated for up to 6000 puffs at 20mg nicotine salt, sold across 56 flavours in the UK, and unaffected by the single use disposable ban because the kit they fit is rechargeable. This guide covers how to choose a flavour, how the mesh coil and nic salt combination actually works, what a pod really costs to run week to week, how to fit one without a dry hit, and what an incoming government duty change means for anyone thinking of stocking up.

 

What are Hayati Pro Max Plus 6K replacement pods, in plain terms?

A Hayati Pro Max Plus 6K replacement pod is the consumable half of the Hayati Pro Max Plus 6000 kit, the part that actually holds and vaporises the e liquid, sold separately from the rechargeable device itself. Each set is a matched pair, a 2ml pod that sits in the device and a 10ml refill container that feeds it, working together as one sealed 12ml unit that is used until empty and then thrown away and replaced whole.

That is different from an open system, where you buy a tank, buy a coil separately, and refill the tank yourself from a bottle of e liquid whenever it runs low. With this pod, there is nothing to fill and nothing to build. You fit a new sealed set, use it until it runs dry, and fit the next one. It is a genuinely lower maintenance system, and that trade off, simplicity in exchange for less manual control over strength and flavour blending, is the main thing to understand before buying in bulk.

If you are still deciding whether you actually need the pods on their own or the full kit as well, our separate guide, Hayati Pro Max Plus 6K kit or replacement pods, which should you buy, covers that decision and the full cost comparison between buying a new kit versus buying pods for one you already own. This guide assumes you already have the device, or are about to, and focuses entirely on getting the most out of the pods themselves.

 

 

Hayati Pro Max Plus 6K pods specifications, and the numbers that actually matter

The specifications on the box are accurate but not very useful on their own. Here is what each figure means once you translate it into real world terms.

Specification	Figure	What it actually means
Active pod capacity	2ml	Sits at the UK legal maximum for a single sealed vaping chamber
Refill container capacity	10ml	The UK legal maximum for one nicotine containing refill container
Total e liquid per set	12ml	Both parts combined, the full amount you get before needing a new set
Nicotine strength	20mg/ml nicotine salt	The UK legal maximum strength, suited to most people who smoked 10 or more cigarettes a day
Puff yield	Up to 6000 puffs	Around 500 puffs per millilitre of e liquid in the set, the figure to use for your own planning
Coil type	Sealed built in mesh coil	Cannot be replaced separately, coil life equals pod life
Draw type	Mouth to lung, draw activated	No fire button, no wattage setting, restricted airflow for a cigarette like pull
Compatible device	Hayati Pro Max Plus 6000 kit only	Will not fit any other manufacturer's device

Three of those figures, the 2ml pod, the 10ml refill container and the 20mg/ml strength, are not just Hayati's specification, they are the absolute ceiling permitted for any nicotine vaping product sold in the UK under the Tobacco and Related Products Regulations 2016. No UK retailer can legally sell a pod bigger than 2ml, a refill container bigger than 10ml, or an e liquid stronger than 20mg/ml, no matter which brand it carries. Once you know that, "12ml total, 20mg nic salt" stops being a marketing number and becomes a statement that this pod is delivering everything the law allows.

 

Why Hayati Pro Max Plus 6K pods use nicotine salt rather than freebase nicotine

Nicotine salt is nicotine bonded with an acid, most commonly benzoic acid, which lowers the liquid's pH and makes a 20mg/ml strength feel noticeably smoother on the throat than the same strength would in freebase form. That chemistry is exactly why prefilled pod systems, including this one, use nic salt almost universally at higher strengths, freebase nicotine at 20mg/ml in a low powered mesh coil pod would be harsh enough that most vapers would struggle to use it comfortably.

The trade off is absorption speed. Nicotine salt tends to be absorbed a little more gradually than freebase nicotine vaped at high wattage in a sub ohm tank, which is part of why pod systems like this one are built around frequent, shorter draws rather than the occasional huge cloud. For a former smoker used to a steady drip of nicotine through the day rather than infrequent large hits, that pattern tends to match smoking's own rhythm more closely than a high wattage device would.

 

Mesh coil against standard coil, why it matters in a Hayati Pro Max Plus 6K pod

The coil sealed inside a Hayati Pro Max Plus 6K pod is a mesh coil, a flat sheet of resistance wire rather than a single round wound wire. Mesh heats more evenly across a larger surface area, which reduces the scorched or muted patches of flavour that older single wire coils were prone to, especially toward the end of a tank or pod's life as the wick starts to dry unevenly.

Because the coil is sealed into the pod itself and cannot be swapped out separately, coil condition and pod condition are the same thing here. There is no separate coil replacement schedule to track, as there would be on an open system tank, the entire pod is replaced once flavour or vapour production drops off, which in practice is almost always at or near the point the 10ml refill container actually runs dry rather than because the coil itself has failed early.

 

Hayati Pro Max Plus 6K pods flavour guide, all four families explained

Fifty six flavours is a genuinely wide range for one closed pod system, wide enough that picking blind can mean a poor first impression. Grouping them by family makes it easier to choose with some confidence.

• Fruit flavours make up the largest group by far, from single note options such as watermelon, mango or blue raspberry, through to layered blends like strawberry watermelon or blue razz cherry. Nic salt fruit blends tend to read sweeter and rounder on the exhale than freebase fruit e liquids, with less of the sharp, almost sour top note some open system juices have.
  
  
• Menthol and ice flavours range from a straightforward fresh mint to double menthol for vapers who want a strong, sinus clearing cold hit rather than a mild coolness in the background. A number of the fruit flavours also carry an ice suffix, layering a cooling finish over a fruit base rather than replacing it, worth checking carefully if you want pure fruit with no menthol at all.
  
  
• Dessert and bakery style flavours, such as custard or sweeter bakery profiles, tend to read heavier and more filling on the exhale, and generally suit vapers who came from richer flavoured cigarettes or who simply prefer a dessert note to a fruit or menthol one.
  
  
• Tobacco leaning flavours are a smaller group within the range, aimed specifically at recent switchers who still want a familiar tobacco note during the first weeks away from cigarettes rather than jumping straight to a sweet or menthol profile.

A small number of flavours across these families are also stocked at 0mg alongside the standard 20mg version, for adult vapers who want the hand to mouth habit and the flavour without nicotine. Availability at 0mg is more limited than at 20mg and changes more often, since turnover on nicotine free stock is naturally lower.

 

Hayati Pro Max Plus 6K pods and MTL, why the draw feels tight on purpose

Every Hayati Pro Max Plus 6K pod is a mouth to lung device, meaning the draw is deliberately restricted, air passes through a small inlet before reaching the mesh coil, producing a tighter pull that most people find closer to drawing on a cigarette than the loose, airy draw of a direct to lung sub ohm tank.

This is a design decision, not a limitation. A restricted, mouth to lung draw is generally what recent switchers from smoking find easiest to adapt to, since it does not require learning an entirely new inhale pattern the way a direct to lung device does. If you specifically want big, visible clouds and an open, airy lung hit draw, this pod, and the kit it fits, will feel wrong from the first puff, and no amount of flavour choice will fix that mismatch. That is worth knowing before buying six or seven flavours at once.

 

Hayati Pro Max Plus 6K pods running cost, worked out by usage rate

Manufacturer puff ratings are tested in controlled conditions, real usage varies with draw length and how often the device sits idle. Working from the 500 puffs per millilitre figure derived earlier, and this product's current £5.25 unit price, here is what four realistic UK usage patterns look like.

Usage profile	Estimated puffs a day	How long one 12ml set lasts	Approximate weekly cost
Light or social vaper	Around 50 puffs	Around 120 days, roughly 17 weeks	Around £0.31
Former 10 a day smoker	Around 120 to 150 puffs	Around 40 to 50 days, roughly 6 to 7 weeks	Around £0.75 to £0.88
Former 20 a day smoker	Around 220 to 260 puffs	Around 23 to 27 days, roughly 3 to 4 weeks	Around £1.36 to £1.60
Heavy vaper, 30 a day equivalent or more	350 puffs or more	17 days or fewer, roughly 2 to 2.5 weeks	£2.16 or more

Taking the former 20 a day smoker row as a worked example, 6000 puffs divided by roughly 240 puffs a day gives about 25 days of use, and £5.25 divided by 3.6 weeks comes to roughly £1.46 a week. These figures are planning estimates rather than guarantees, since draw length and how often the device is left idle both change real yield, but they are considerably more useful than the bare "up to 6000 puffs" figure printed on the packaging.

 

Should you stock up on Hayati Pro Max Plus 6K pods before October 2026?

From 1 October 2026, a new UK Vaping Products Duty applies a flat rate of £2.20 per 10ml of vaping liquid, regardless of nicotine strength, confirmed on the GOV.UK Vaping Products Duty policy paper. A 12ml Hayati Pro Max Plus 6K pod set contains 1.2 times that base 10ml unit, so the duty adds roughly £2.64 to the underlying cost of producing each set, a cost that retailers across the UK, not only this one, are expected to reflect in shelf prices from October onward.

Retailers who already hold wholesale stock that has cleared duty registration before the cutover can continue selling it under the prior pricing structure for a limited transitional period, so a genuine, near term price rise is realistic rather than speculative for products bought after the duty takes effect. As of the end of August 2026, that change is roughly a month away, which makes now a reasonable point for anyone who reorders this pod regularly to consider buying slightly ahead of their normal reorder cycle rather than waiting until stock actually runs out in October or later.

This is a genuine, sensible piece of planning advice, not a countdown pressure tactic. If you already reorder every four to six weeks in the normal course of using this pod, bringing that one order forward by a couple of weeks avoids paying the new duty on that particular batch, without needing to buy an unreasonably large stockpile you will not get through before flavour and coil condition start to matter.

 

How to fit a Hayati Pro Max Plus 6K pod without a dry hit or a leak

Most first day problems with a brand new Hayati Pro Max Plus 6K pod trace back to one of two things, a sealing tab left in place, or not giving the mesh coil time to saturate before drawing hard.

1. Check the base and the airflow inlet of the pod for a small rubber or silicone tab fitted to stop leaking in transit, and remove it completely, this single step prevents most "no vapour" complaints on a fresh pod.
   
   
2. Line up the pod's connector pins with the device's contacts before pushing it in, the pod only seats correctly one way round.
   
   
3. Push the pod firmly and squarely into the Hayati Pro Max Plus 6000 kit until it clicks or sits flush, rather than forcing it in at an angle.
   
   
4. Wait two to three minutes before the first draw, giving the mesh coil time to fully saturate with e liquid from the connected refill container.
   
   
5. Take several short, gentle draws rather than one long pull for the first few puffs, which significantly reduces the chance of a flooded, gurgling pod straight out of the packet.

 

Hayati Pro Max Plus 6K pods troubleshooting, five problems and their fixes

These five issues account for most of the support queries this shop receives about this specific pod, and every one has a straightforward fix.

• No vapour on a brand new pod. Almost always a sealing tab left on the airflow inlet or base contacts. Remove it fully and try again.
  
  
• A burnt or harsh taste from the first draw. Usually caused by drawing too soon after fitting, before the mesh coil has saturated. Wait two to three minutes and take gentle first puffs rather than a long, hard pull.
  
  
• Gurgling or a wet, bubbling sound. Typically a sign of a flooded coil, often from drawing too hard on a brand new pod or vaping at an angle that lets e liquid pool over the coil. Wipe any visible liquid from the mouthpiece and let the pod sit upright for a few minutes before trying again.
  
  
• Weak flavour or thin vapour toward the end of a pod's life. This is normal as the refill container empties, but if it happens early, well before you would expect the 6000 puff rating to be reached, check the pod is seated fully and the connector pins are making clean contact.
  
  
• The pod will not click into the device, or the device will not fire. Check the pod is the correct orientation and that the connector pins on both the pod and the device are clean and undamaged, a pod forced in at an angle can bend a pin and cause poor or no contact even though the pod itself is not faulty.

 

Who actually buys Hayati Pro Max Plus 6K pods, four real scenarios

A returning customer who bought the Hayati Pro Max Plus 6000 kit two months ago and is now placing their third routine pod reorder, having settled on two or three favourite flavours from the 56 on offer, is the single most common buyer of this product.

Someone six weeks into switching from a 20 a day smoking habit, checking the running cost table above to work out roughly how often they will need to reorder and budgeting for it as a recurring weekly cost rather than a surprise.

A UK vaper stocking up ahead of a weekend away where buying more pods will not be convenient, choosing two or three sealed sets in different flavours rather than relying on finding a shop while travelling.

An existing kit owner buying a first order of pods for a partner or another verified adult household member who has also decided to switch, after passing this site's own age verification separately for that order.

 

Who Hayati Pro Max Plus 6K pods are not right for

If you do not already own, or are not about to buy, the Hayati Pro Max Plus 6K Kit, these pods are the wrong purchase, they are refill stock for an existing device, not a starting point.

If you want big clouds and a loose, open lung hit draw, this pod will disappoint you regardless of flavour, the mesh coil and restricted airflow are built specifically for mouth to lung vaping.

If you want to step nicotine strength down gradually in small increments, for example from 20mg to 10mg, this exact pod range does not currently stock a 10mg option on this site, only 0mg and 20mg, so a compatible refillable device using our separate Nic Salts range would suit that goal better.

If you would rather choose and mix your own e liquid rather than use sealed prefilled sets, an open system device from our Vape Pod Kits collection gives you that manual control, at the cost of doing your own refilling and coil changes.

This product is for adult smokers and vapers aged 18 and over only, and is never suitable for anyone under 18.

 

Hayati Pro Max Plus 6K pods against the alternatives

Option	Type	Effort required	Best suited to
Hayati Pro Max Plus 6K pods	Closed pod, sealed prefilled	Fit and forget, no refilling or coil changes	Existing kit owners who want a wide flavour range with zero maintenance
Other closed pod kits in our Prefilled Pod Kits range	Closed pod, sealed prefilled	Same low effort, different brand and puff tier	Vapers wanting to compare flavour profiles across brands
Open system pod kits	Refillable	Manual refilling from a bottle, occasional coil changes	Vapers who want full control over which e liquid brand they use
A different manufacturer's closed pod system	Closed pod, sealed prefilled	Fit and forget, but not cross compatible with Hayati devices	Owners of a different brand's kit specifically

The one constant across every closed pod system on the market, this one included, is that pods and kits are matched pairs. A Hayati Pro Max Plus 6K pod is engineered around this device's specific connector pin layout, pod cavity dimensions and airflow calibration, and will not fit any other manufacturer's kit, in the same way no other brand's pod will fit this one.

 

Storing Hayati Pro Max Plus 6K pods correctly before you open them

Sealed and unopened, this pod holds its flavour and nicotine strength well if kept somewhere cool and out of direct sunlight, a cupboard or a drawer is entirely sufficient, nothing more specialised is needed. What genuinely does affect a sealed pod is prolonged heat, leaving a bulk order in a hot car for a summer weekend can affect both the mesh wicking material and the flavour concentration over time, worth bearing in mind if you buy several sets at once to save on repeat postage or ahead of the October duty change discussed above.

Buying in bulk only makes practical sense if you will actually get through the stock within a few months of normal use, rather than leaving several unopened sets sitting for a year or more.

 

Mistakes people make ordering Hayati Pro Max Plus 6K pods

Ordering the wrong nicotine strength out of habit is the most common mistake, particularly for anyone reordering on autopilot after recently stepping down strength or trying a 0mg flavour for the first time.

Assuming any pod will fit the device is a close second, some customers new to closed pod systems try to fit a different brand's pod they already had lying around, which will not seat correctly and can bend a connector pin if forced.

Leaving a reorder until the pod is already flat and burnt tasting rather than ordering a few days ahead, particularly relevant now that most repeat customers reorder online rather than picking up in person, since UK delivery, even next day, still takes a day or two to arrive.

Not checking flavour availability before committing to a large multi flavour order, since a handful of the 56 flavours in this range, particularly some of the 0mg options, are more prone to running out of stock than the core 20mg range.

 

Are Hayati Pro Max Plus 6K pods legal in the UK?

Yes. Hayati Pro Max Plus 6K pods, and the rechargeable kit they are made for, are unaffected by the UK's disposable vape ban, which took effect on 1 June 2025 and applies specifically to devices with no rechargeable battery and no replaceable pod that are simply thrown away whole once empty. This is a rechargeable, pod based system, so it falls outside that ban entirely.

The pod also sits within every current UK limit set out under the Tobacco and Related Products Regulations 2016, 2ml pod capacity, 10ml refill container capacity, and 20mg/ml nicotine strength, as confirmed on the GOV.UK guidance on e cigarette regulations for consumer products. Every product sold on this site, including this pod, is notified to the Medicines and Healthcare products Regulatory Agency under the TRPR notification scheme before it is ever listed, and any UK vaper can check a product's own notification status directly on the MHRA ECIG Dynamic Search database, the official public register of notified vaping products.

This product contains nicotine which is a highly addictive substance. It is for adult smokers and vapers aged 18 and over only, and this guide makes no claim that vaping is safe, healthy or a smoking cessation treatment.

 

Hayati Pro Max Plus 6K pods, our verdict

For an existing Hayati Pro Max Plus 6000 kit owner, this pod does what a well built closed pod refill should, consistent flavour delivery from a mesh coil across a genuinely wide 56 flavour range, sitting at the legal maximum for capacity and strength so there is nothing left on the table a compliant UK pod could offer. Running cost is competitive, from roughly 31 pence a week for a light vaper up to around £2.16 a week for a heavy user, and the fit and priming steps above solve the vast majority of first day problems before they start.

It is not the right pick for a cloud chaser, for someone wanting a mid strength 10mg step in this exact SKU, or for anyone who has not yet decided between this closed system and an open, refillable alternative. For that decision specifically, our kit versus pods comparison guide and the Hayati Pro Max Plus 6K Kit product page are the better starting points.

 

About the reviewer, Daniel Marsh

Daniel Marsh has worked in UK vape retail since 2017 and personally tests every device before it goes live on Prefilled Vapes Outlet, focusing on real world battery life, coil performance and day to day reliability rather than marketing claims. He follows UK vaping regulation closely, including TRPR, MHRA notification and TPD compliance, as part of his day to day role choosing what the site stocks. This guide draws on his own testing notes on fit consistency across the Hayati Pro Max Plus 6K flavour range and how the pod performs as the refill container runs down toward empty.

 

Hayati Pro Max Plus 6K pods frequently asked questions

1. How many puffs does a Hayati Pro Max Plus 6K pod give?
   Up to 6000 puffs per pod and refill set on the manufacturer's stated rating, working out to roughly 500 puffs per millilitre across the 12ml total. Real world puff counts vary with draw length and how often the device sits idle between uses.
   
   
2. What is the total e liquid capacity of a Hayati Pro Max Plus 6K pod?
   12ml in total, made up of a 2ml active pod and a connected 10ml refill container. Both figures sit at the legal maximum UK law allows for a pod and a refill container respectively.
   
   
3. Will Hayati Pro Max Plus 6K pods get more expensive in October 2026?
   Likely, though the exact retail adjustment is up to each retailer. A new UK Vaping Products Duty of £2.20 per 10ml applies from 1 October 2026, adding roughly £2.64 in underlying duty cost to a 12ml pod set, which is expected to be reflected in shelf prices from that date.
   
   
4. Can a Hayati Pro Max Plus 6K pod be used in a different device?
   No. It is built specifically for the Hayati Pro Max Plus 6000 kit and will not fit any other manufacturer's device, closed pod systems are engineered as matched pairs and are not cross compatible.
   
   
5. Why does a new Hayati Pro Max Plus 6K pod taste burnt?
   Almost always caused by drawing too soon after fitting, before the mesh coil has fully saturated. Wait two to three minutes after fitting and take gentle first puffs rather than a long, hard pull.
   
   
6. What nicotine strengths are available in Hayati Pro Max Plus 6K pods?
   The current UK range on this site is stocked at 20mg nicotine salt, with a smaller number of flavours also available at 0mg. There is no 10mg option in this specific pod range at present.
   
   
7. Are Hayati Pro Max Plus 6K pods affected by the UK disposable vape ban?
   No. The ban that took effect on 1 June 2025 applies to single use disposable devices with no rechargeable battery and no replaceable pod. The Hayati Pro Max Plus 6000 kit is rechargeable and its pods are replaceable, so the system falls outside the ban entirely.
   
   
8. How do I know if I need the Hayati Pro Max Plus 6K kit or just the pods?
   If you do not already own a Hayati Pro Max Plus 6000 device, you need the kit first, pods alone will not work without it. If you already own the kit and it still functions normally, you only need pods. Our full kit versus pods comparison covers this decision in detail.